NIARMADA Nissan Armada manuals & owner information
Nissan Armada owner resource

Manuals, service information and practical owner guidance.

Fast access to Nissan Armada manuals, operating instructions, maintenance references and technical information.

Browse manuals →
Nissan Armada manual library

Nissan Armada 2025-2026 Service and Repair Manual: Front Oil Seal

Nissan Armada 2025-2026 Service and Repair Manual / Engine / Engine Mechanical / Front Oil Seal

Removal and Installation

WARNING:

  • Jacking up or lift up the vehicle may the vehicle height to go down which cause a personal injury and/or damage to the air suspension component parts. Refer to Precaution for when Jacking and Lifting Up the vehicle with Electronic Air Suspension System.

REMOVAL

Remove the following parts:

  • Front under cover using a power tool (commercial service tool). Refer to Removal and Installation.

  • Drive belt: Refer to Removal & Installation.

  • Crankshaft pulley: Refer to Removal & Installation.

Remove front oil seal using a suitable tool.

CAUTION:

Never damage front cover and crankshaft.

INSTALLATION

Apply new engine oil to both oil seal lip and dust seal lip of new front oil seal.

Install front oil seal.

  • Install front oil seal so that each seal lip is oriented as shown in the figure.

    : Oil seal lip
    : Dust seal lip
    : Engine inside
    : Engine outside

  • Press in front oil seal to the position as shown in the figure.

    : Front cover rear end face
    : 0 - 0.5 mm (0 - 0.020 in)

  • Using a suitable drift, press-fit until the height of front oil seal is level with the mounting surface.

    • Suitable drift: outer diameter 60 mm (2.36 in), inner diameter 50 mm (1.97 in).

  • Check that the garter spring is in position and seal lips are not inverted.

CAUTION:

  • Never damage front cover and crankshaft.

  • Press-fit straight and avoid causing burrs or tilting oil seal.

Install in the reverse order of removal after this step.

    Other materials

    Precautions for Supplemental Restraint System (srs) Air Bag and Seat Belt Pre-Te
    PRECAUTIONS FOR SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG AND SEAT BELT PRE-TENSIONER : Precautions The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along with a front seat belt, helps to reduce the risk or severity of injury to the driver and front p ...

    Passenger Knee Air Bag Module
    Exploded View Steering member Passenger knee air bag module     : Always replace after every disassembly. : N·m (kg-m, in-lb) Removal and Installation WARNING: Always observe the following items for preventing accidental activation. Before servicing, ignition switch OFF, ...

    Driver Side
    Diagnosis Procedure CHECK DRIVER SIDE DOOR MIRROR DEFOGGER Check driver side door mirror defogger. Refer to Component Function Check. Is the inspection result normal? YES>> GO TO 2. NO>> Repair or replace the malfunctioning parts. CONFIRM THE OPERATION Confirm the operation again. Is t ...